At Passmasters, we know the fastest way to ruin a ride isn’t a slow bike — it’s a bike that’s been neglected.
If your chain’s screaming for lube, your tyres are flatter than last night’s beer, and your brakes sound like a metal band warming up, no amount of fancy bolt-ons will save you.
The truth is, the best performance upgrade you can give your bike is proper maintenance.
It’s cheaper than replacing parts early, keeps you safer, and means you can actually focus on the ride instead of worrying if that noise is “normal”.
So, here’s our no-nonsense guide to keeping your ride in peak condition — Passmasters style.
1. Tyres: Where the Rubber Meets the Road
Your tyres are the only thing connecting you to the road — or dirt — so treat them like the VIPs they are.
-
Check before every ride: Look for cuts, bulges, embedded objects, and make sure tread depth is healthy (legal limit is 1.5mm, but we say change at 2mm).
-
Pressure matters: Under-inflated tyres handle like a shopping trolley with a wonky wheel. Check at least weekly and adjust for pillions or luggage.
-
Age counts: Even with good tread, tyres older than five years lose grip. Replace them before they betray you mid-corner.
Passmasters Tip: Cold tyres are like cold beer — you need to warm them up before you get the best out of them.
2. Chain Care: The Unsung Hero
A clean, well-lubed chain = smooth power delivery and less wallet damage.
-
Clean every 1,000–1,500km: Use a chain cleaner and a stiff nylon brush (never wire).
-
Lube every 300km: Best done after a ride while the chain is warm, spraying on the inside run.
-
Adjust slack: Too tight and you stress bearings; too loose and you get jerky power. Check your manual for exact specs.
Passmasters Tip: If you can pull the chain away from the rear sprocket and see daylight, it’s time for a new one.
3. Oil: Liquid Gold for Your Engine
Your oil doesn’t just lubricate — it cools and cleans, too.
-
Check weekly: Make sure the bike’s upright on level ground when checking.
-
Change on time (or early): Stick to your service intervals. Old oil loses its ability to protect, and cheap oil changes are way cheaper than engine rebuilds.
-
Use the right grade: Synthetic or semi-synthetic for most modern bikes. Ask if unsure — your engine will thank you.
4. Brakes: Your Last Line of Defence
You can go as fast as you want — as long as you can stop.
-
Check pads: Replace if they’re thinner than 2–3mm.
-
Inspect discs: Look for grooves, rust, or warping.
-
Change fluid: Every 1–2 years. Brake fluid absorbs moisture, which kills performance and corrodes parts.
-
Upgrade lines: Braided lines give firmer feel and more consistent braking.
5. Suspension: Smooth Operator
Good suspension keeps your tyres gripping and your backside comfortable.
-
Test bounce: Push down on the front brake and seat — you want firm resistance and smooth rebound.
-
Check fork seals: Any oil on the stanchions means they’re leaking.
-
Keep it clean: Mud and grit shorten suspension life.
Passmasters Tip: Bad suspension can feel like bad tyres, so don’t blame your rubber until you’ve checked your shocks and forks.
6. Cables, Controls & Stands
Everything should move freely and easily.
-
Lubricate clutch and throttle cables: Dry cables feel notchy and can stick.
-
Adjust lever reach: Comfort = control.
-
Grease pivot points: Side stand, centre stand, and lever pivots.
7. Lights & Electrics
Because being seen is just as important as seeing.
-
Check all lights before riding: Headlight, brake lights, indicators.
-
Replace dodgy bulbs early: Don’t wait for them to blow mid-ride.
-
Battery health: Keep terminals clean, charge if the bike sits for weeks.
Bonus: Upgrades & Mods
Once your maintenance is sorted, you can think about fun extras.
-
Exhausts: Better sound, maybe more power. Just keep it legal.
-
ECU remaps: Fine-tune fuelling for performance parts.
-
Suspension upgrades: Transform handling on budget bikes.
-
Brakes: Braided lines and high-friction pads for sharper stops.
-
Luggage & comfort gear: Tank bags, heated grips, aftermarket screens.
Remember — upgrades are the icing, not the cake. Maintenance is the cake. Nobody likes dry cake.
Passmasters Final Word
Your bike’s health is your responsibility. If you keep on top of tyres, chain, oil, brakes, suspension, and controls, you’ll have a machine that’s safer, smoother, and more fun to ride.
And if you’re not sure how to do it yourself? No shame in that — bring it in, ask questions, and we’ll keep you rolling. After all, a happy bike means a happy rider.
Feel free to download our checklist below: